TM 10-3510-209-10
Section IV. OPERATION UNDER UNUSUAL CONDITIONS
Para
Title
Page
2-12
Operation in Extreme Cold......................................................................................
2-78
2-13
Operation in Dust or Sand.......................................................................................
2-79
2-14
Operation in Snow and Mud....................................................................................
2-79
2-15
Operation in Saltwater Areas .................................................................................
2-79
2-16
Emergency Procedures...........................................................................................
2-79
2-12. OPERATION IN EXTREME COLD (BELOW 0°F or -18°C)
WARNING
Do not touch cold metal parts with bare hands. Cold metal parts can cause
frostbite and injury to personnel.
CAUTION
Subzero temperatures cause rubber and metal parts to become brittle and prone to
breakage. Use proper lubrication for extreme cold operations.
a.
Lubrication of Generator Set. Refer to TM 5-6115-585-12 for proper lubrication in extreme cold
(below 0°F or -18°C).
b.
Lubrication of Laundry Unit. Ensure the laundry unit has been lubricated in accordance with LO 10-
3510-209-12 for the air temperature expected.
c.
Operation in Extreme Cold. During operation in extreme cold, steps must be taken to protect the
equipment from freezing. Operate the unit inside a tent or other suitable enclosure if necessary.
Water must be supplied without exposing the water pump or water hose to below-freezing
temperatures. After operation in extreme cold, perform the following:
(1)
Shut down and drain water heater and water pump (refer to para 2-9e).
(2)
Disconnect and drain hoses (refer to para 2-10).
(3)
With the washer and compressor operating, switch the hot water and cold water switches on
the controller to manual position, with drain switch open and master switch at manual. Allow
2 minutes to drain all water from the washer.
(4)
Open the drain valve under the compressor air supply tank and drain condensation.
(5)
Load the trailer and store it in a heated shelter if possible.
2-78
