TM 10-3510-209-24
SYMPTOM INDEX (Cont)
Troubleshooting
Procedures
(Page)
WATER HEATER (CONT)
12.
Water heater smoke escapes from around boiler box cover ........................................................
2-36
13.
Water heater temperature gage shows water
exceeds set temperature ......................................................................................................
2-37
14.
Water heater is discharging through drain tube while in use ........................................................
2-38
15.
Water heater blower is noisy .....................................................................................................
2-38
WATER PUMP
16.
Water pump shaft fails to rotate .................................................................................................
2-38
EXTRACTOR
17.
Extractor fails to start ...............................................................................................................
2-39
18.
Extractor starts but basket fails to turn .......................................................................................
2-40
19.
Extractor runs on too long .........................................................................................................
2-40
20.
Extractor rotates in clockwise direction ......................................................................................
2-41
21.
Extractor is noisy or accelerates too quickly ...............................................................................
2-41
22.
Extractor has water on or around base ......................................................................................
2-41
DRYER ASSEMBLY
23.
Dryer tumbler does not rotate ....................................................................................................
2-42
24.
Dryer air is not heated to the correct temperature .......................................................................
2-42
25.
Dryer burner flame fails ............................................................................................................
2-43
26.
Dryer-tumbler burner does not operate ......................................................................................
2-45
27.
Dryer fuel pressure (as indicated on gage) pulsates ...................................................................
2-45
28.
Dryer flame pulsates ................................................................................................................
2-46
29.
Excessive smoke from dryer exhaust ........................................................................................
2-46
30.
Air leaks from dryer door ..........................................................................................................
2-47
AIR COMPRESSOR
31.
Compressor does not operate ...................................................................................................
2-48
32.
Air pressure is too low (below 60 psi [414 kPa]) or to high
(above 80 psi [552 kPa]) ......................................................................................................
2-48
WASHER ASSEMBLY
33.
Washer will not fill and cylinder will not rotate .............................................................................
2-49
34.
Washer fill level is too low .........................................................................................................
2-50
35.
Washer fill level is too high .......................................................................................................
2-53
36.
Water will not drain from washer ...............................................................................................
2-53
37.
Washer will not fill with cold/hot water
(automatic or manual mode) .................................................................................................
2-53
38.
Washer cylinder will not rotate
(automatic or manual mode) .................................................................................................
2-54
39.
Water leaks around washer door ...............................................................................................
2-54
2-24
