TM 10-3510-222-24
UNIT MALFUNCTION INDEX
MALFUNCTION
PAGE
Table 2-2. UNIT LAUNDRY UNIT MAIN POWER
TROUBLESHOOTING PROCEDURES
1.
No power to component circuit breakers ......................................................................................................
2-19
Table 2-3. UNIT WASHER TROUBLESHOOTING PROCEDURES
1.
Washer will not operate ...............................................................................................................................
2-20
2.
Water will not drain from washer ..................................................................................................................
2-20
3.
Washer fill level too low ...............................................................................................................................
2-21
4.
Washer fill level too high/water runs out of overflow ....................................................................................
2-21
5.
Washer door will not open ............................................................................................................................
2-22
6.
Washer does not fill with cold/hot water (automatic or manual mode) ..........................................................
2-22
7.
Washer cylinder will not rotate (automatic or manual mode) .......................................................................
2-22
Table 2-4. UNIT AIR COMPRESSOR
TROUBLESHOOTING PROCEDURES
1.
Air Compressor fails to start .........................................................................................................................
2-23
2.
Air Compressor fails to deliver air pressure ..................................................................................................
2-24
3.
Air pressure below 90 psi or above 100 psi ..................................................................................................
2-24
Table 2-5. UNIT DRYER TROUBLESHOOTING PROCEDURES
1.
Dryer fails to start .........................................................................................................................................
2-25
2.
Dryer fails to dry laundry ..............................................................................................................................
2-25
3.
Dryer burner flame fails ...............................................................................................................................
2-25
4.
Dryer tumbler does not rotate .......................................................................................................................
2-26
5.
Dryer fuel pressure (as indicated on gage) pulsates .....................................................................................
2-26
6.
Dryer flame pulsates ....................................................................................................................................
2-26
7.
Excessive smoke from dryer exhaust ...........................................................................................................
2-27
8.
Air leaks from dryer door ..............................................................................................................................
2-27
Table 2-6. UNIT EXTRACTOR TROUBLESHOOTING PROCEDURES
1.
Extractor fails to start ...................................................................................................................................
2-28
2.
Extractor starts but basket fails to turn .........................................................................................................
2-28
3.
Extractor fails to drain ..................................................................................................................................
2-28
Table 2-7. UNIT CENTRIFUGAL PUMP
UNIT TROUBLESHOOTING PROCEDURES
1.
Centrifugal pump unit fails to start ................................................................................................................
2-29
2.
Centrifugal pump unit fails to deliver water ..................................................................................................
2-30
2-18
