TM 10-3510-208-12
Time
Water
(includes
filling &
temperature
Water
level
draining)
Detergent
(approx.)
Operation
7. Preextract . .
...........................
10 sec . . ...4.....
drain remains open.
.....................
...........................
8. Extract . . . . . . .
5 min . . . . . . . . . . . .
.....................
drain remains open.
9. Brake to com-
plete stop.
NOTE
Water levels are average with fully loaded washer in motion. Allow for absorption before first suds.
Table 2-4. Wool Wash Formula for Manual Operation
I
I
Time
Water
(includes
filling&
temperature
Detergent
Operation
Water level
draining)
(approx.)
100F. (38C.) . . . . . . . . . . .
6oz. (168gr)
l. Suds . . . . . . . . .
ll in. (27.94 cm) . . . . . . . . . . . . .
5 min . . . . . . . . . . . .
100F . . . . . . . . . . . . . . . . .
3 oz. (84 gr)
2. Suds . . . . . . . . .
l1 in . . . . . . . . . . . . . . . . . . . . . . .
5 min . . . . . . . . . . . .
100F . . . . . . . . . . . . . . . . .
3. Suds . . . . . . . . .
5 min . . . . . . . . . . . .
2oz. (56gr)
l1 in . . . . . . . . . . . . . . . . . . . . . . .
2 min . . . . . . . . . . . .
100F. (38C.)
4. Rinse . . . . . . . .
ll in. (27.94 cm) . . . . . . . . . . . . .
100F.
5. Rinse . . . . . . . .
2 min . . . . . . . . . . . .
l1 in . . . . . . . . . . . . . . . . . . . . . . .
6. Rinse . . . . . . . .
2 min . . . . . . . . . . . .
100F . . . . . . . . . . . . . . . . .
l1 in . . . . . . . . . . . . . . . . . . . . . . .
open drain valve
after l l/2 min.
.....................
...........................
7. Preextract . . . .
10 sec . . . . . . . . . . .
drain remains open.
.................... .......
.....................
8. Extract. . . . . . .
drain remains open.
5 sec . . . . . . . . . . . .
9. Brake to com-
plete stop.
NOTE
When filling or draining washer, it must be stopped to prevent damage to woolen items.
5. Turn the AUTO-MANUAL switch to
pre-extract-extract cycle. Depress the signal switch
the AUTO position.
and hold it down until the signal finger leaves No.
14 slot of the control record. Allow the switch to
sounds and the signal light comes on, the
return to its normal position, and the pre-extract-
operator's attendance at the control panel is
extract cycle will begin automatically. In the case
mandatory. The operator must stand by to add
of extremely rough extraction, push the AUTO-
washing supplies when using a multi-suds formula,
MANUAL control switch to the MANUAL
to initiate the pre-extract-extract phase, to take
position and push the BRAKE-DRAIN switch (fig.
corrective measures in the case of rough ex-
2-5) to the BRAKE position. After the washer-
traction, and to remove the wash at the end of the
extractor door locking pin returns to the unlocked
washing cycle.
position, push the AUTO-MANUAL switch to the
7. When using a multi-suds formula, the
OFF position, and turn the control record until the
warning bell will sound and the signal light will go
finger contacts the beginning of the pre-extract-
out to summon the operator to add more washing
extract (No. 4) slot. Push the AUTO-MANUAL
supplies. After the supplies are added through the
switch to the AUTO position to pre-extract and
supply lid, depress the signal switch (fig. 2-6),
extract the load. In case of subsequent rough
extractions, continue to repeat the precedures
hold it down for 10 seconds, and release the
switch. If the warning bell still sounds after the
described above until the extraction is smooth.
switch is released, repeat the procedure until the
9. The warning bell will sound at the
bell stops ringing (until signal finger leaves No. 14
completion of the formula to signal the operator
slot of the control record (fig. 2-6)).
that the load should be withdrawn from the
8. At the completion of the washing
washer-extractor.
(rinse) cycle but just before the start of the pre-
10. Repeat washing-extraction operations
extract -extract cycle, the bell will sound end the
with the remaining loads in a similar manner.
signal light will go out. The operator's presence at
(b) Manual Operation.
the control panel is again mandatory to initiate the
1. Load the washer with 60 pounds (27
2-23
